Arctic Chat : Arctic Cat Forum banner
z570

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-9 of 11 Results
  1. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Trying to replace all 4 drive bearings in my 2006 z570lx. When reassembling I could not remember or figure out where the v ring seal for the chain case goes on the driveshaft. I have a service manual but it mentions nothing about a seal and one definitely came off of the sled when disassembled...
  2. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    hello all. i ave an 02 z570 the kids ride. it has the SS supsension and is shot. can i replace that rear shock with a non smartride shock?
  3. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a 02' Z 570, and I have taken and replaced the secondary spring from a stock yellow, to a red sping and tightend the tension on it. My quesition is... What else can I do to my clutching, primary or secondary, to get more speed?
  4. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a 2002 Z 570, I have rebuilt the engine twice, replaced the a-arms with some performance a-arms, I have rejetted, regeared it (23 top 39 bottom), studded the track with 48 studs, put on C&A Pro3 Ski's, tightend the clutch spring to the last spring hole, and replace the belt with a racing...
  5. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a 2002 Z 570 with stock gearing (19 top, 39 bottom) and I am getting around 85-90 mph and I was wondering if I can change up my gearing to increase my top speed....? Or what else I can do to increase my speed.
  6. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a 2002 Z 570 that I have been loving for years now. It's got about 5,000 miles on it, I am not too sure... the speedo went out 2 years ago. It had never had any major problems until this year. Other then body and undercarriage issues, this year the engine burnt up, but it was just the...
  7. Performance/Racing
    Guys, Do anyone of you happen to have the Arctic cat Performance Manuals for the years 2002 to 2005? Can you check whether any of these manuals contain Grass Drag Race Setup for the Z570? If so, which year? Thx
  8. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hey, I have an 02 Z 570 Light Weight that I just put used rebuilt fox shocks on the front, and a ZR rebuilt rears, movement in the rear is slightly limited but the problem I have is at speed 40+MPH it gets squirrely, alignment is good track is good skis and wear bars are good, could there be to...
  9. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Sled was going great for the past few weeks did 100 miles yesterday and no problems and today I went 12 miles stopped and filled up the gas, only took 1.3 gallons and checked the oil, it was fine. went about 4 more miles and on a straight away it just died out on me. the pull cord was hanging...
1-9 of 11 Results
Top