Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 23 Results
  1. Vintage 1992 & Older
    yes i saw there is another post about this but none of the links work on that post. This is a tough one to ask, the Alley cat that i got has some wiring issues, it has spark but its always grounding out to the engine not between the electrodes of the spark plug, so i think it comes down to the...
  2. Sled Mods & Tech-Tips
    I built a dragster and put a 1000 thundercat engine in the back. I have it running but I can't figure out the wiring to get the charging system to work. Most specifically, the 4 wires that come off the stator. 2 yellow, a brown and and black. The way that a guy at the track had me do it is to...
  3. Utility ATV repair, maintenance, troubleshooting
    Hello, I am trying to fix some terrible wiring on a 2008 400 FIS Auto I bought recently. A previous owner butchered the wiring harness and made it power up with a flip switch and then pull start only. I bought a new ignition switch and solenoid but have to re-wire a new connector to the...
  4. General ATV Discussion
    Hey everyone. Just bought a 2004 arctic cat 250 4x4 for my daughter and was told it needed a starter relay. Bought a new 1 but old 1 was removed by old owner. My question is:: which way does it mount in and what wires go to the terminals i have a green wire a double black wire and battery and...
  5. Utility ATV repair, maintenance, troubleshooting
    Hello - I am in the UK and just picked up an 06 250 Utility that had a seized engine and is missing some parts along with the wiring being severely mucked about with. I own a few other quads so am not unfamiliar with how to work on them, but this one is making me tear my hair out! I have...
  6. Arctic Cat Snowmobiles
    So I recently purchased a project. It's a 1980 john deere liquifer chassis with a 89 wildcat 650 engine and wire harness. It also has 00 powder special rear skid chaincase ect. My question is about wiring the hand warmers. I have no wire harness that went to the bars on the wildcat harness...
  7. Vintage 1992 & Older
    What does the two wires going into the gear case go to and what reason
  8. General ATV Discussion
    I have a 2007 Arctic Cat 650 H1 TBX and the ignition switch has locked with no movement of the key and does not work at all. I took the instrument pod off in hopes that it was simply "get a new switch" and plug it into the wiring harness as shown in the diagram from A/C parthouse but in reality...
  9. Panther/Pantera/T570/Touring
    I need help finding a wiring diagram or how to hot wire my machine. It has some wires shorting out causing it to run rough and have dim lights. If I bend the harness the right way it runs good but lights are still dim. I would like to simplify things, be able to turn it on and off and a...
  10. Vintage 1992 & Older
    I have a 1993 700 Wildcat EFI that is having a charging problem. The batter drains at night if we do not disconnect it from the sled (the battery is good). When we turn the sled on the battery light no longer comes on, but the headlights come on. The sled will run for about 15-20 minutes...
  11. Firecat/Sabercat
    During my last ride of last season my gauge pod flickered a few times then stopped working completely. I figured it was a bad gauge pod and purchased a new 1. That's apparently not the problem. Next I replaced the wiring harness from the module to the gauge pod, it's still not working. The sled...
  12. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    i put a illuminated switch on instead of my key switch because i lost my key and am too cheap to buy a new switch, but is there a wire i can tap into to light the switch?
  13. M Series/Mountain Cat Pre 2011
    Like in the title I'm curious if 05/06 wiring harness are interchangable? I'm putting a new one in my 05 m7 and noticed there is quite a difference in pricing. They have different part numbers, but looking at the diagrams it looks like there is only one extra plug, and even that is only a loop...
  14. Utility ATV repair, maintenance, troubleshooting
    I have been fighting an issue with my 1999 Artic Cat 250 ATV all summer. Up till yesterday, the bike ran crappy until it seemed what ever was stuck in the carberator cleared itself out. This has been going on all summer with new gas, adding sea foam, clearing lines. I thought it was a fuel...
  15. Utility ATV repair, maintenance, troubleshooting
    I have a 2012 artic cat 450i that I rolled dodging a dog. The wiring to the back of the LCD cluster was damaged. I ordered a new LCD cluster and the cluster repair harness. However, not all the wires match up. there are only seven wires coming off the main harness and there are 20 wires on the...
  16. Utility ATV repair, maintenance, troubleshooting
    1999 artic cat 300 with suzuki motor, I can't get to stay running unless I turn on my head lights or brake light. don't have any idea where to start.
  17. Vintage 1992 & Older
    I picked up a 73 Panther and all wires were cut coming out of the motor and were just hanging there. I would like to know if anyone has a wiring diagram and/or pictures on how the wires get hooked back up. Pictures would be great! If you have any available and would be willing to share,please...
  18. Firecat/Sabercat
    I picked up a 2003 Sno pro 440 that had a 03 F7 efi motor and wiring harness. I picked the F7 motor and harness out and sold them. Really struggling with the wiring up front for the 440. I have a 03 440 harness that origanly came out of the sled, along with the original motor. I cannot figure...
  19. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    my 99 zl500 carb. wont shut off with the key switch or kill switch. there is no power in the purple wire at the switch. is my CDI bad or something else? thanks
  20. Firecat/Sabercat
    I am in great need of a repair manual (wiring diagram for the cdi unit 23 pins, well everything) Ive got wiring diagrams for all -05 arctic but not the sno pro 440.:wacko: Ive called like all stores in the country but they cant get me one. Can anyone help me please?
1-20 of 23 Results
Top