Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-8 of 9 Results
  1. Utility ATV repair, maintenance, troubleshooting
    i have a 1999-2001 arctic cat 450 and its stuck in 5th gear the transmission is manual do you have any idea what the problem could be?
  2. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I'm concerned that my ZR is using up too much fuel. I used about 10 gallons in 40 miles of riding down back roads. So I'm estimating 4 mpg. I recently fixed a flooding issue which ended up being a leaking needle valve o-ring. I replaced the pistons about 80 miles ago ( 2 years ago) after...
  3. Utility ATV repair, maintenance, troubleshooting
    Hey all new here, was driving around the yard, turned the wheeler off now it will not start again. It has gas to the carb. We have replaced the battery, spark plug, magneto, ignition coil, rectifier, and CDI. The starter and starter relay tested voltage to within spec, valve clearance, fuses and...
  4. Utility ATV repair, maintenance, troubleshooting
    I have a Arctic cat 300 and it starts fine but when i go to move it, it wont move. Idles fine but when i go to move, it acts like its in reverse safety mode (it does not have one) and starts chugging to the point the transmission wont engage. If anyone knows anything about this issue let me know.
  5. General ATV Discussion
    I have an 04 arctic cat 400. I have replaced the flywheel, stator, and voltage regulator because a magnet came off and chewed up the stator. When trying to start it, I turned the key on, and no lights at all, no power to the instrument cluster. I have checked all the fuses and every ground I...
  6. Utility ATV repair, maintenance, troubleshooting
    Hi, I have a 2000 Arctic Cat 500 4x4 I recently had some work and a full tuneup done and it was running great then one day when I went to start it the starter would just click The lights and radiator turn on and the pull start working fine I read it is probably the battery? Can anyone confirm...
  7. Utility ATV repair, maintenance, troubleshooting
    I have removed and cleaned the carburetor twice. I made sure all the jets were clean, blew everything out real well, and set the pilot screw according to the specs., Good gas is getting to the float bowl, but my '05 500 TBX still won't start. When I spray starter fluid into the carb, she...
  8. M Series/Mountain Cat Pre 2011
    Hi, I just brought home a 2001 Mountain Cat and found that there are no working lights (headlight,taillight,electrical gauges, hand/thumb warmers). Sled runs fine, but possibly stator issue? can someone tell me the specs for testing the stator? Or, any other ideas???
1-8 of 9 Results
Top