Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 30 Results
  1. Arctic Cat Snowmobiles
    First post, been doing a lot of reading in here and was hoping for some help. Basically I'm looking for answers on what stators I can use to replace mine. On a 2013 m800 sno pro 153". What years can I look to use? They all seem to be 3007-711 from about 2010-2017. I get the same part replacement...
  2. Arctic Cat Snowmobiles
    I just got a 1999 pantera 580 efi. No battery installed because I don’t have starter in it. Cleaned up the engine and exhaust, new plugs cleaned fuel rail and injectors. Compression is 100 and 98. Not perfect I know, I’ll rebuild someday, but she starts within 3 pulls every time, issue...
  3. Utility ATV repair, maintenance, troubleshooting
    Hey guys Picked up a 2001 Arctic cat 500 4x4 with 600km on it recently and it’s got a few issues. One of the major ones is that the battery won’t hold a charge. I put a brand new battery in which worked for a short time but now I get no power. Wondering if it is the stator? Is there a way of...
  4. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hello I recently acquired a 99 600 zl efi. It has a d&d chip & single pipe. Riding it around the yard I noticed that I won't rev above 7000 rpm. I did alot of research determined that the high side ignition coil on the stator was out of spec. I'm bought one from caltric stator and it burned...
  5. Panther/Pantera/T570/Touring
    I got a new cdi box and used a good coil pack changed out the kill switch and looked at the ignition switch but with the electric start its hard to make out what is what. when i pull the cord the head light flickers so i dont think it is the stator. can anyone help me?? has anyone had the same...
  6. General ATV Discussion
    Does any one know if the correct part number for a 2004 Arctic Cat 400 FIS Stator is #3430-053.... And does the Suzuki eiger Part #32101-38F00 Fit? Also is there a cover plate that can be used on the speedometer gears? And if so where can you get it? Thanks a Ton guys
  7. General ATV Discussion
    Hi everyone, I have acquired a 2004 arctic cat 400 fis. It runs great for about 15 mins and then dies. wont start again until it cools.I have read about the dreaded flywheel magneto issue so I took the cover off to check it out. To my surprise it has been changed to the new style rotor. Now my...
  8. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I am hoping someone can help. I have a 1996 zr580 efi, that started and ran great at the end of last season, but needed a new stator. I replaced the stator with a used stator I found online, and put in a new battery. When I went to start it up, it just would not go. I have fuel to the engine...
  9. Utility ATV repair, maintenance, troubleshooting
    What I have in the Shop is a 2005 Arctic Cat 400 Auto. Customer brought in the quad with no spark. First we tried the CDI and that was not the issue then we found out about the flywheel issues on the AC 400 and the Eigers so we pulled the cover and found that our Flywheel Magnets had came loose...
  10. Polaris / Ski-Doo / Yamaha General Forum
    I'm trying to fix a buddies 97 Skandik 500. It will start and go, but it won't stay idling on both cylinders. It will start on 2 then drop one. You can limp it up to speed and around 25-30 mph the second cylinder will pick up. It runs great at high speeds. I thought maybe carb, but I hooked...
  11. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Does anyone have the ohm measurements for the stator on an Arctic Cat 2004 Z 570 fan-cooled motor? I have traced my sled's inability to be turned off with the key switch or the kill switch to either the stator, or the CDI box. To take it to the next step, I need the specs to figure this out. Or...
  12. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have been trying to fix my 2003 zr 600 with no luck!!! i have a twin to it so swapping parts is not a problem. The sled runs great with the wires from the stator pluged in but as soon as you do it bucks then stalls!! I have changed the tps, throttle with no luck. Could it just be a bad...
  13. Firecat/Sabercat
    so after having issues with loosing headlights and grips ect last winter i bought a new stator and installed it this past weekend on my 2004 snow pro with a 2004 f6 efi swap after getting everything back together i go to start it and as always second pull it fires and then dies instantly. This...
  14. Utility ATV repair, maintenance, troubleshooting
    2005 400 4x4 Automatic, No Spark. Spark plug is good, I have 2 coils, both test fine, boot and wire to coil is fine. New CDI Box, I also pulled the crankcase cover, all magnets are in place on the flywheel and all of the little magnets on the stator? look good. Battery is freshly charged, when...
  15. Utility ATV repair, maintenance, troubleshooting
    I have a 1993 kawasaki bayou 220 and one of the stator ignition coils is broke does any one here offer rewind service and how much thank you
  16. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hello, I have a 1996 ZRT 600 with what appears to be a bad stator. I sent the stator in to be rewound and have received it back. I reinstalled stator, but now the sled won't start (it would at least start before sending the stator in). I pulled the stator and re-checked the resistance specs...
  17. Firecat/Sabercat
    What up fellas, Been awhile since Ive had problems but here goes. I have an 05 F7 EFI SP. Boondocker w twin speedwerx pipes. Havnet rode it in two years. It was put away for those years as u normally would at the end of that winter. Fuel isnt stale Power valves are clean. No obvious problems...
  18. Vintage 1992 & Older
    I picked up a 73 Panther and all wires were cut coming out of the motor and were just hanging there. I would like to know if anyone has a wiring diagram and/or pictures on how the wires get hooked back up. Pictures would be great! If you have any available and would be willing to share,please...
  19. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I suspect my stator may be bad so i want to test it on the sled. Do i have to disconnect everything attached to the stator to test it or can i just unplug the white 3 wire(brown green black) I ask this because here are my readings on an ice cold stator... brown/green 430 --should be 450..is this...
  20. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    have a zr 600 2002 and need a new flywheel and wondering if i could lighten it up with a 440 flywheel? anyone have any input on this area? thanks
1-20 of 30 Results
Top