Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-7 of 8 Results
  1. Arctic Cat Snowmobiles
    Was riding my sled (06 Crossfire 600) a couple weekends ago and heard a pop while going full throttle across a lake. Afterwards I started getting a grinding or rattling noise when taking off from a dead stop. I popped the hood when I got home and found the whole outer layer of the belt was...
  2. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hey guys, I have a 03 ZR 900 that i recently replaced the jack shaft on. So I had to obviously take the secondary off, all the gears in the chain case and the top bearing inside the chain case. After about an hour of trying to get the jack shaft out (holy rust!) I’m finally ready to reassemble...
  3. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    hey guys. went out for another ride the other day and every time i tried holding it wide open there would be a loud bang coming from the secondary clutch. and i noticed that there is about a quarter inch gap between the bolt that holds the secondary clutch on and the clutch itself. i have no...
  4. CrossFire/CF/CFR 06-11
    I have a freind that recently purchased the bmp complete torsional conversion kit for his 2006 crossfire 700 efi 136" track. After installing this kit on the sled and trying several different adjustments he just can't seem to get anymore performance out of the sled. Just looking for some good...
  5. Firecat/Sabercat
    Hey guys, I have a 2004 Sabercat 700. I was riding doing about 50 mph, and all of a sudden I heard a clunk and the power just drained right out from underneath me. I came to a stop and when i tried to hit the throttle the engine just rev up to 3500-4000 RPM and wouldn't move. I...
  6. Firecat/Sabercat
    Hi, I have a question about my secondary clutch. I took it off the machine and inspected and cleaned it up - getting ready for when the snow comes. Everything looks good. My question is should I put a bit of grease on the shaft where the two sections slide apart from one another? I'm...
  7. Firecat/Sabercat
    Hi i have an 05 F-5 bought this sled this summer have had many problems to get it to run good. Now that it does i had to set belt deflection was running way to low. Now that i have that set it goes alot better but now it'll rev 8475 this seems way to high to me. My crossfire only turns...
1-7 of 8 Results
Top