Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-18 of 41 Results
  1. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hi all! Slow winter here in NY without any snow. Doing an engine swap on an 01 ZR800 and putting in an 02 500 engine. Now I have done the swap of making a 500 an 800 and now going the other way. my only issue is the front motor mounts. They don't mount on top of the rail like the 800...
  2. Utility ATV repair, maintenance, troubleshooting
    Hi Everyone I have a 1998 454 that has an engine problem once it is warmed up. It starts and runs fine until warmed up then it starts to lose rpms and sounds like it starts misfiring and stalls. It will not restart until the engine cools back down and the same thing happens again. It happens...
  3. Prowler
    Hey everyone. So have a bit of a nightmare. 2 years ago my 2011 hdx prowler 700 decided to split the head and had bad play i bottom end. Took it to a "I can fix it cheaper" guy who didnt know what they were doing yes I know stupidity on my part. But now i have a box of parts and no on really...
  4. Utility ATV repair, maintenance, troubleshooting
    Evening Guys I have got a 2007 AC 400 4x4 Automatic TRV plus I am trying to figure out the correct Spark plug for this engine? Is there a stamp on the cylinder anywhere as well? I think its the 376cm3. Shes running a bit lean i think as well as exhaust gets very hot ? Could anyone shed any...
  5. F/M/XF/ZR Procross Chassis 2012+
    Howdy all, Got myself in a pickle here. I have a trip planned for tomorrow and the chances of making it are looking slim. Blew a top end last weekend on PTO side. The looks of the piston appear it overheated and/or cold seize. It has 4 scuffs with even distance from each other. There is even...
  6. General Snowmobile Discussion
    Just looking for some suggestions & thoughts on a situation I’m possibly in? Sorry for the long story below I have 94 Wildcat EFI, over the weekend while I was hitting some trails, sled all of a sudden started to bog bad so I cut the motor, found that my coolant was almost completely gone &...
  7. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I bought this ‘99 ZR700 that had a broken 9 tower primary clutch. The rest of the sled is in really good condition. I got a good used 9 tower off a buddy which I seen him drive his parts sled around so I know the clutch is good. The problem is, when I have the back on a jack, clutch engages and...
  8. Arctic Cat Snowmobiles
    How hard should it be to turn the engine over if you are turning it over by hand with the primary clutch? Easy or hard? Sled has 2200 miles on it
  9. General ATV Discussion
    I've got a 06 artic cat and I'm trying to figure out who made the engine. All Google tells me is that in 2010 they cut ties with Suzuki to make their own but that was about snowmobiles. Did Suzuki also make the quad engines?
  10. Utility ATV repair, maintenance, troubleshooting
    I just acquired a 2006 650 v2 via trade. Cat happyI traded a smoking and knocking wolverine 350 for it. The v2 supposedly just needs rod bearings and put back together.:Bangin: the guy I got it from said that the rod bearings could be replaced without splitting the cases. my question is what...
  11. General ATV Discussion
    I'm looking for a used Crankcase for my 2006 650 H1. Does anybody know where I can get a used left side crankcase with magneto cover. If I can figure out how to post the picture, you can see the starter gears have been removed because the pin holding them in place blew out. The guy I bought...
  12. General ATV Discussion
    I have a 2007 arctic cat 500 and I am installing an 2006 650 top end on it. I have got the jug milled down to match stroke I am just now trying to figure out what to do about an exhaust and Carb. I need to replace the pipe and muffler just wondering which may be a good one to go with. Then with...
  13. F Series Twin Spar Chassis 07-20
    Hey everyone. I have a 2006 440 sno pro. I was riding it the other day and it droped a cylinder, did some tests and found that it lost spark in one side. we replaced the ignition coil and the plugs and that seemed to work. I took it out for the first time after the repair and it did the same...
  14. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Looking for a engine for my 02 zr 800 would like a big twin mine smoked rod bearing and broke lower case either a complete engine or a lower end anything would help prefer Michigan or upper Wisconsin as I have a place in both thanks
  15. Vintage 1992 & Older
    Ok hello everyone, I am having engine issues with my 1980 el tigre 6000 500. The other night while riding antifreeze began spraying out of my radiator over flow. I took the head off of the engine to inspect the head gasket and found two things.. The cylinder's (on the side of the rope) head...
  16. Vintage 1992 & Older
    Hi all, My sled is blowing anti freeze out of the radiator cap. The cap is not bad, as we have replaced it with another one. The temp Gage went to hot and the motor started missing. Does this mean the radiator is bad or are we talking about something even worse such as a head gasket or a...
  17. General Snowmobile Discussion
    i was driving my 2001 Zr 600 and i came to a stop.. when i tryed to move again smoke came out of the hood and made a high pitch noise.. and it wouldnt move... what did i do???
  18. Utility ATV repair, maintenance, troubleshooting
    Hello guys i have had my mudpro now sitting in my garage for a while , i spun my main bearing on low oil so i need an engine rebult on my 2010 700 mud pro. Anyone know any good mechanics in the houston tx area,..... Really wanna get it going or anyone selling an engine
1-18 of 41 Results
Top