Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-17 of 31 Results
  1. Utility ATV repair, maintenance, troubleshooting
    Hi Everyone I have a 1998 454 that has an engine problem once it is warmed up. It starts and runs fine until warmed up then it starts to lose rpms and sounds like it starts misfiring and stalls. It will not restart until the engine cools back down and the same thing happens again. It happens...
  2. SnoPro Chassis 08-14 600/13-14 500
    I have cooked me ecu on my 2012 sno pro 600. I am in the market for a used one that will work for my sled. My question is what years are compatible to plug in and work? and is there any way to cross reference numbers on them?. I dont mind needing to reflash the new/used one I find. Thank you...
  3. DVX Repair Forum
    It starts and runs great for a few seconds then begins to skip every other firing cycle and will not speed up. More throttle just makes it fire harder. I checked with a timing light and it is visible by the light's flashes. Sometimes it will skip more than one cycle. I checked the coil and...
  4. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I am putting a 2000 zr 600 motor (carburated) in a 1998 zl 500 (carburated) chassis. I am using the 600 stator, CDI unit and wiring harness. The 600 wiring harness has an extra 3 prong plug that the 500 did not. What is this extra plug for and will this run if I just leave it hanging unplugged?
  5. Panther/Pantera/T570/Touring
    I got a new cdi box and used a good coil pack changed out the kill switch and looked at the ignition switch but with the electric start its hard to make out what is what. when i pull the cord the head light flickers so i dont think it is the stator. can anyone help me?? has anyone had the same...
  6. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have replaced the stator on my EXT 580 EFI due to a low speed coil resistance of 177 ohms. Still won't start and no spark. Rechecked new stator and it is within specs. Ignition coil and trigger coil are in spec as well :wacko: Is it possible that the bad stator took out the CDI unit? Any...
  7. Utility ATV repair, maintenance, troubleshooting
    So you see a lot of posts on here about limp mode. Well let's break limp mode down for people who may not be mechanically saavy. Your ATV may be equipped with a fail safe that we call "limp mode". What happens is that your machine has thrown a semi-serious to a serious code through your ecu/cdi...
  8. General ATV Discussion
    Hello all, I am new to the ATV world. In fact I am borrowing one and had the worst situation possible develop. A friend sent me to his cabin (lives elsewhere) to get his ATV to borrow for plowing my driveway. Before leaving his place, I jumped the machine with my truck (bad idea???) and plowed...
  9. Utility Performance / Technical info
    I have a 1999 Arctic Cat 400 2x4 that has a bad CDI box. Does anyone out there have a good one laying around or know of somewhere I can buy one for a reasonable price. I don't want to pay $575 for one! Thanks in advance! Also, is there possibly one from another machine that also will work?
  10. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    hey I have a 2000 zr 440 sno pro. its not running right. it has a clutch kit so it engages at like 5500 rpm... its puking oil out of the exhaust. it has new needles and seats. it has 280 main jets in it...and it smokes kind of a lot....also it seems like the clutch side cylinder is getting...
  11. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    i just recently purchased a 2000 zr 440 sno pro... and the cdi box was afloat under the clutch... does anyone know where the cdi is actually supposed to mount please help.. thank you
  12. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I recently aquired a 95 thundercat with a high speed stator coil shorted to ground. I replaced the coil and gave a few pulls and the machine fired but would not run. I checked the new high speed coil and it was now shorted to ground. The only thing I can think of is the CDI is sending a high...
  13. Utility Performance / Technical info
    last weekend I was out riding my 07 700 efi. Was playing in some water and it got a little deep. The bike didnt stall or anything and after 20 mins of riding I shut it off to take a break. The bike never started again. After cranking a while it started throwing a bunch of codes. Seemed to be the...
  14. Utility ATV repair, maintenance, troubleshooting
    My Atv has a brand new carb and I cleaned the gas tank and fuel line filters prior to installing carb. The atv ran great for about a month with me putting about 20 miles on it and then all of a sudden I started it one day and it beagan cutting out at full throttle. I drained the fuel and sprayed...
  15. Utility ATV repair, maintenance, troubleshooting
    This weekend's ride came to a premature end when the rev limiter suddenly limited me to 3500-4000rpm (25-30kph). Conditions at the time were uneventful - no big speed, no water, 2wd easy going but all at once tried to accelerate and couldn't. Have since confirmed the usual items including...
  16. Utility Performance / Technical info
    Does a 650 h1 prowler cdi rev box work on a 650 h1 trv ???????????????????? Both are single cylinder. Need to know as soon as possible going to Uwharrie this weekend.
  17. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a spark problem. Sometimes I get spark and sometimes I don't. I disconnected main wiring harness. Checked plugs, caps, ignition coils, wires - all within spec. I checked the stator coils and they are within spec. I bought a new CDI and it doesn't solve the problem. I have checked...
1-17 of 31 Results
Top