Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-18 of 24 Results
  1. Panther/Pantera/T570/Touring
    Hey All- Picked up free 2001 Panther 370 with a seized engine (everything else is in perfect condition). I have a 550 from a 1994 Pantera (EFI) that has low miles and I drove it all over the lake last winter, so I know its good (1542 miles). I looked up the part numbers and the 1994 550 engine...
  2. Panther/Pantera/T570/Touring
    I Have an 02 Pantera 550 with 14,500 (yes) original miles. Only thing ever done to it is regular maintenance! It even has the original track. It was my dad's and I would like to keep it trail worthy. Last year I took it for a short spin on the lake and it was smoking significantly spitting out...
  3. ATV Tires and Wheels
    Hi all, I'm looking to replace the worn tires of my 2013 550 XT ATV and am wondering about variability of tire choices without having to upgrade any equipment. Stock tires/rims on the unit are 25x8x12 and 25x10x12 but I'm not sure what other tire sizes those rims and the unit's cowell size...
  4. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hey everybody, got a question that I'm sure has been asked, but I did some searching and can't find it. I was changing brake pads on my '96 Cougar 550 2-up today, and right as I'm finishing up, my spring clip pliers yeet the clip into the abyss. Does anybody happen to know the size and/or...
  5. General ATV Discussion
    So my 550 developed a clicking/clunking sound from the clutch area. I first notice it while driving fwd or reverse. I put it on stands and left it in neutral, reved engine and you can hear it slightly. If i turn the driveshaft a bit it will make the clicking/clunking sound, i turn it again it...
  6. Utility ATV repair, maintenance, troubleshooting
    Hey guys, new here to the site and a new Cat owner. I recently bought a 2014 550 EFI with a 165 miles on it, yep you read that right. A guy used it a couple times to plow his driveway and then went with a snowblower instead. It's never even been registered. It didn't take me long to pull the...
    550
  7. Utility ATV repair, maintenance, troubleshooting
    I have had this ATV since new, and no work done on the system before. It has an intermittent issue with starting for years but getting worse. Cranks but no start or have to cycle power. No Codes. There are times it starts right up and then times it will not start at all. When it is running it...
  8. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hello, I am new to snowmobiles and got a 92 ext special and had no issues for a week or so. A noise had started up, and I had no power, when I opened the chaincase, I found that one side of the spring tensioner was no longer in the spring. Sadly, I can't seem to find just the spring tensioner...
  9. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hey guys, I have a 2003 ZL 550 that has been in the family since it was new. It is a great running sled and starts on 1 or 2 pulls on all but the coldest days, but will not idle until warm. Unless you stay by the sled and keep blipping the throttle the idle will drop lower and lower and until it...
  10. General ATV Discussion
    Hello guys, First post here, as I am out of options. I am trying to fix up a 2010 550 H1 TRV EFI. When I bought it someone had done some really crappy wiring to the ISC and it wrecked the ISC. I have a new one installed but need to know which wire from the harness goes to which position on...
  11. Utility Performance / Technical info
    Ok so my 2009 550 H1 EFI started blowing ignition fuses. I found a rub back by fuse box and temporarily repaired. It was good for about a week and then it did it again. I learned that it was the foot brake so I unplugged it and all is well. Then I went riding and about an hr into it I hit this...
  12. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    so ive been trying to look around to see what my 93 ac ext 550 should have for compression and the only thing i could find was 135psi per cylinder, wasnt sure what was good, i know anyless than 100psi is bad and more than a 10 difference isnt good but i wasnt sure from there
  13. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    i just got my 93 ext in my garage to rebuild and was noticing the lack of suspension, if anyone knows a way to ajust the rear to sit higher it would be much appriciated.
  14. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a 93 EXT 550 and am working on getting it running again after 2-3 years, as im starting I went to take the seat off and could only find 2 bolts but it seems like theres more than that.
  15. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Have a 1995 550 arctic cat. Was riding down trail yesterday after about one and half hours of riding, motor just turned off. No sputters bangs or pops. Just off like someone hit the kill switch. Checked for spark and no spark. Jumped out the safty switch and key switch with a jumper from 2...
  16. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I am currently experiencing issues with overheating and looking for a little advice. Originally I thought it was a thermostat issue but that checked out fine. I topped off the coolant and "burped" the system which seems to fix the problem of the coolant light coming on at startup and while...
  17. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    1993 Arctic Cat Pantera 550 EFI Wondering what will cause 6V to go thru to ground on the EFI circuit? Iam guessing bad DC voltage regulator. I had a hand warmer switch that i replaced because (thought this was the original problem but i dont think so anymore still having problem after replacing...
  18. M Series/Mountain Cat Pre 2011
    I've got an old cougar mtn cat, it's no modern bike for sure, but its a hoot on my sealevel powder. Anybody have one of these? Got buddy who spruced one up? Stretched it out, or geared it differently? I'm bored and sunburnt so i apparently need another project.... I'm not a speed freak, I'm...
1-18 of 24 Results
Top