Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-13 of 17 Results
  1. Utility ATV repair, maintenance, troubleshooting
    The rear drive/propeller shaft on our 2005 Arctic Cat 400 ATV needs to be replaced because the splines wore down. I've obtained the new shaft, boot, clamps, etc. (see highlights in picture below), but in the service manual, I can't find any mention about the boot replacement. Does there need to...
  2. Utility Performance / Technical info
    Hello, I had recently purchased a 2004 400. Rode it for about 40 miles on a fresh rebuild. Was messing around in my gravel pit and when going onto the trailer it died. Was able to jump it to unload and get into garage, but ever since then I cannot get it to crank. Dash has low voltage. Replaced...
  3. Utility ATV repair, maintenance, troubleshooting
    Hi there, On my arctic cat 400 automatic there is a switch for R-N-H-L but it wont read N on the dash anymore. It shows - or E. But it wont start wen it is not in E. I have found the 6/5 pin connector for the switch but i dont know the combinations for the N signal. If i can make a external...
  4. General ATV Discussion
    Hi guys, bought an 06 400 and it was great untill.....these two issues. 1. Instrument panel keeps restarting. I hit some deeper water than I wanted too..so now it keeps restarting and sometimes it says volt. It stays backlit constantly, however the info on the panel only stays on for 10...
  5. Utility ATV repair, maintenance, troubleshooting
    On the way back from riding the machine got stuck in 3rd gear. It didn't want to go Into any gear even when the bike was turned off it didn't want to shift. Any one run into this problem before? I can still drive it but it doesn't shift. I try rocking it but nothing. I just it it like 2 week ago
  6. Utility ATV repair, maintenance, troubleshooting
    A little background, - I bought this 2003 arctic cat 400 4x4 FIS a few weeks ago and changed out the flywheel (magnets shot), new spark plug, filters ect, and cleaned out the carb. I got it to start and it ran ok for a few minutes, drove it around the house and then it started to bog out, no...
  7. General ATV Discussion
    2005 400 4 x 4 auto LE Differential lock worked great all this summer. Had a bad CV axle. Took it to the dealer to have that replaced and tighten diff lock cable. Get aTV back; notice a clicking noise when turning to the right with four-wheel-drive engaged. Engaged and disengaged locking...
  8. Utility Performance / Technical info
    I have a 1999 Arctic Cat 400 2x4 that has a bad CDI box. Does anyone out there have a good one laying around or know of somewhere I can buy one for a reasonable price. I don't want to pay $575 for one! Thanks in advance! Also, is there possibly one from another machine that also will work?
  9. Utility Performance / Technical info
    New here so go easy. 2004 400 Automatic 4X4 recently purchased and looking to install a winch. Picked up a new Mile Marker PE3500 for $50 from a local shop that had it in stock for some reason. Purchased a mount from KFI (which is on its way) and trying to figure out and plan where this is...
  10. General ATV Discussion
    Howdy Y'all~ I'm new to this, so please bear with Me... Just got this and I'm trying to find out if The 'Cat that I have is a "FIS, TBX, TRV, DVX, or VP"... ? Nothing on the DMV reg or title has this info and I'm confused... I'm just trying to replace the battery right now, but I'm looking to...
  11. Utility ATV repair, maintenance, troubleshooting
    Ok I have a '03 400 4x4 that is leaking fuel from the overflow.. I recently cleaned the carb, replaced the float valve, reset the float to 17mm, put an inline fuel filter on it, repalced the fuel line, removed fuel tank and completely drained the pint/quart of water hidden in it. it ran fine 2...
  12. Utility Performance / Technical info
    so i have a 2004 400 4x4 auto arctic cat and i have snorkled it, runs good. But when i get over the rack after a wile it starts to sputter and act like its going to shut off. I have been told its the electronicts getting wet? Is the something that can be done to stop this?
  13. Utility Performance / Technical info
    i have a 2006 400 automatic 4x4 i am wanting to put a clutch kit in for more of a response when i hit the gas. I need a a kit i can put in it? i am also wanting to put a snorkel kit or possibly make one but need some directions.
1-13 of 17 Results
Top