Arctic Chat : Arctic Cat Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-15 of 16 Results
  1. Arctic Cat Snowmobiles
    My 1999 ZL 600 cuts out between 5-6000 rpm give it more throttle it runs fine, less throttle runs fine, seems right around that rpm it cuts in and out I’m assuming it’s spark because it just cuts out for a second then runs fine if I let off or give it more, and seems only after its warmed up...
  2. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Looking for some advice on my new build. I have a 1999 powder special 700 and am looking to get some more power out of it. I have seen a lot of people recommending twin pipes but haven’t found a company that makes them. Does anyone know what pipes will fit. Also any other recommendations? I...
  3. Utility ATV repair, maintenance, troubleshooting
    So I've recently picked up a 1999 arctic cat 500 4x4 which I thought was in decent running condition. Was able to take it for a test ride and seem to idle and run well at the time. First night out after about 20 minutes it started to back fire a decent amount when ever I let off the throttle and...
  4. Arctic Cat Snowmobiles
    Howdy. Just rebuilding my thundercat and the previous owner blew it up so I’m putting it back together. But on the water pump, I was wondering if anyone knew what size bolt goes on the impeller shaft and also there’s a washer and a seal that goes on that bolt. I have the seal but is the washer...
  5. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I have a '99 440 Sno Pro, only has about 1/3 throttle. Starts and idles and runs great at low speeds, but around 30 mph or going past about 1/3 throttle, it simply doesn't increase speed/power. My first thought was a bad fuel pump, or leak in the pump line from the engine. Any thoughts, or...
  6. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hello all, I am new here and just bought my first sled, a 1999 Arctic Cat ZRT 800. I have some experience riding however this is the first ine I have owned personally. Anyways, the sled is in good condition overall and only has 4060 miles on it. It has D and D pipes however and I want ot just...
  7. Utility ATV repair, maintenance, troubleshooting
    I have been fighting an issue with my 1999 Artic Cat 250 ATV all summer. Up till yesterday, the bike ran crappy until it seemed what ever was stuck in the carberator cleared itself out. This has been going on all summer with new gas, adding sea foam, clearing lines. I thought it was a fuel...
  8. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I was riding my 99 ZL 500 on rough trails last weekend. There were two of us on it. After riding for two or three hours, then getting off, I noticed the sled appeared to be sitting very low. In fact, it was sitting about an inch from bottom rather than having the usual 6 or so inches of travel...
  9. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    hi, i have a 1999 zrt 600 and it wont start outside in the cold but will start inside. when i start it in my garage it will start but wont go very far then i try and start it outside and it seems like it starts to run on 2 cylinders. is this a fouled plug issue or is there something wrong with...
  10. Utility Performance / Technical info
    This is a thread to help those who may have questions with their older chassis AC ATV, mine is a 1999 400, and I've done a few modifications, including a snorkel, which I will post the snorkel information in the pinned 'snorkel' section. I just wanted to lay out a few custom things I have done...
  11. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Well, thanks to posts here I got my sled (99 ZL500) running, but now there's no snow here in the deep south (oshawa, on). Since I don't suppose I'll find anymore riding this year (unless there's some suggestions out there), does anyone have any suggestions for putting it away for the summer...
  12. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    Hi all, I'm new to posting here, but been reading the forum for a while waiting for this fateful day, the day my 1999 Sno Pro decided to eat all 4 of the power valves. The second set.... Suffice to say, I have read extensively on this topic and fully expected the power valves to fail at some...
  13. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    I am looking for a y pipe for a 1999 zr 700. also curious. the flanges on mine that bolt up to the engine run str8 across. as they should because this is the only way they will bolt up to a twin 700. However when i look the part up for order the diagram shows that the flanges are slanted. is...
  14. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    1999 was 24/39 2000 was 23/40 ...if I can get just the sprockets/gears, can I use the 1999 chain w/the 2000 gears?
  15. Z/ZL/ZR/ZRT/T-Cat/EXT/JAG/Cougar
    hey guys i was just wondering what the best upgrade for a 1998 zl 500 would be. im just gettin a little sick of it not being as snappy as i would like it, anything would help.thanksI dunno
1-15 of 16 Results
Top