650h1 will rev but barely moves! - ArcticChat.com - Arctic Cat Forum


Utility Performance / Technical info Utility ATV Performance and Technical Discussions about specific mods, engine upgrades!

Reply
Old 06-18-2010, 09:09 AM   #1
Junior Member
 
Junior Member
Join Date: Mar 2009
Location: Cold lake Alberta
Thanks: 0
Thanked 0 Times in 0 Posts
So heres my question ..

I have a 2007 650h1 and this problem seems to be getting alot worse everytime...

I press the throttle about 1/4 way and the bike starts to rev up but wont move at all...then eventualy
around 1/2 throllte it kicks in and jerks forward, once it gets going its fine. In a mud puddle it will jerk really
bad and wont spin the tires like it has no power at all.

The belt was changed and is not sliping, also this dosent seem to happen when i go reverse seems to work fine

Any ideas on what I could take apart or order?
flexstyle is offline   Reply With Quote
Remove Ads
Old 06-18-2010, 11:49 AM   #2
Senior Member
 
splat10's Avatar
 
Senior Member
Join Date: Jan 2005
Location: Wilton, NY
Thanks: 8
Thanked 13 Times in 13 Posts
Sled: 12 XF800sp Retro
10-11 Mileage: 2000
09-10 Mileage: 1200
08-09 Mileage: 2300
07-08 Mileage: 1800
06-07 Mileage: 1950
ATV: 07 H1 650
2009 Mileage: 400
2008 Mileage: 200
did you put non-wet clutch approved oil in it?

sounds like your clutch (not the pulleys) inside the motor is slipping and not engaging.
__________________
Splat10's Youtube Channel
Visit my clubs!
Mulleyville Snowmobile Club and North Country ATV

2007 H1 650.................................................. ...2012 XF800 Sno Pro
1200+ Miiles.................................................. ...3000+ Miles (only 1 belt)
25x8x12 GBC Dirt Tamers all ........ ....................ZBroz Exit Rear Skid Shock
ITP Delta Steel Rims ....................................,...Center skid revalve
2" air intake Snorkel w/ Dyno Jet Kit...................Powder Pro Skis
Carb Slide Drilled and Clipped
Mechinical Temperature and Volt gauges
Full Aluminum Skid and CV plates
3000 lb Gorilla Winch
splat10 is offline   Reply With Quote
Old 06-18-2010, 11:58 AM   #3
Team ArcticChat
 
Savageman69's Avatar
Team ArcticChat  
Team ArcticChat
Join Date: Mar 2007
Location: Exeter, Ontario, Canada
Thanks: 11
Thanked 448 Times in 420 Posts
Sled: 2014 ZR 7000 LIMITED
ATV: 2007 Arctic Cat 700 EFI
Yep i agree sounds like the wet clutch is toast.
__________________
-------------------
Mark


2014 Arctic Cat ZR 7000 Limited
Float Guards - RaceWerx Quick Seat Kit - Battery Tender Hook Up - Hids - Nuvi 500 - SnowTrackers - BDX Rotor - 7.5 Riser - Skid Plate - Airbox Mod - Pantera Shield Kit - Handle Bar Bag - NGK10ek Plugs - Thicker Oil Pan - Odyssey PC680 - J&T Tri-Hub Delete - 16 Track Spring
2007 Arctic Cat 700 EFI
Warn 3000lb _ -Snorkels - Rad Relocate - Uni Filter - 16G Rollers - 1 mm Primary Shim - EPI Green Secondary Spring - 2.5mm Machined Primary - M109R Injector - VDI Copperhead Ecu - Cat Agm - Bedlined Bumpers & Racks - M109R Motor Mounts - Upper Bump Stop Mod - Skull Shifter - Led Tail - 6k hid & led hi - Engine Ice - Heat Shielded Side Panels - Iridium plug - Sanny Steerlite Full Bushings - Sanny Shock Bushings - Foot Brake Delete - 4x 1200lm led floods - Rigid Sr led 6inch Bar - MP Shocks and Springs - Looped Crank Case Vent/Fuel Tank/Rad Overflow - Sealed Cluster - Custom Exhaust(3inch Outlet) - Front/Rear Mp1000 Axles - RDC Rear Diff Cover - Camoplast tatou 4s - Rad Cap Gauge - Volt Gauge - Symtec Heated Grips - Fuel Filter - A-Arm & Hub Grease Mod - Orange Shock Covers - Front Drive Shaft Loop - 1.5 Lift - HL Arched Tie Rods - LE Pod/LE Plastics - D&D Billet Gas Cap - Billet Res Cover - TigerTail - Rear Diff Brace - Hd Stator
Savageman69 is offline   Reply With Quote
Old 06-19-2010, 02:05 AM   #4
Member
 
mj350's Avatar
 
Member
Join Date: Nov 2009
Location: Whonnock, BC
Thanks: 0
Thanked 0 Times in 0 Posts
ATV: 2007 650h1 trv
2010 Mileage: 2000+
2009 Mileage: 2
x2, definitely sounds like the wet clutch. It should move just above idle/
__________________
Wheres the fun keeping it stock?
I'm here to chew bubble gum and kick a$$!

Caster Mod
Exhaust mod with custom tip
Dyno jet
Uni Filter
Custom 2" lift
2" snokles
27" XTR's
4500# Viper max winch with green synthetic rope and hawse lead
2500# Quadtrax winch - Moved to rear
Symtec heated grips and thumb
Kolphin 15l rack top fuel tank
Yuasa agm battery - king quad replacement, fits TRV box, 18ah and 270cc amps
Arctic cat front bash bumper
1.5" White faced water temp and oil pressure gauges. Green back light
Racked rad
Exhaust snorkel
55w DDM Tuning HID's with 8000k Bulbs
Mud Pro Shocks and Springs
Custom Bent All Balls HD Tie Rods
mj350 is offline   Reply With Quote
Old 06-19-2010, 05:28 PM   #5
Team ArcticChat
 
BTI's Avatar
Team ArcticChat  
Team ArcticChat
Join Date: Sep 2008
Location: Nelsontucky
Thanks: 0
Thanked 3 Times in 3 Posts
Sled: Rose Bud
07-08 Mileage: 25yrds
06-07 Mileage: 35 yrds
ATV: '08 AC 500 TRV
2008 Mileage: 500
2007 Mileage: 400
2006 Mileage: 000
What oil are you running in it?
When did you change it last?

BTI
__________________
2008 Lime Green Twins- 500 'Zuki engine and 650H1 both are TRV's-One sporting 28" Swamp Fox pluses on stock wheels and one with AC 8 spokes and 26.5 Pitbull Rockers, both clutches cut, with drilled rollers, snorkled.
1996 Dodge 2500 X-Cab-4x4-Cummins 12v to pull them with.
BTI is offline   Reply With Quote
Reply

Lower Navigation
Go Back   ArcticChat.com - Arctic Cat Forum » ATV's » Utility ATV repair and maintenance & Troubleshooting » Utility Performance / Technical info


Search tags for this page

07 arctic cat 400 revs up but doesnt move

,

arctic cat 650 barely moving

,

arctic cat atv rev up hardly moves

,
artic cat 500 revs up but doesnt move fast
,
atv barely moves but engine runs fine
,
atv wont barely moves under load
,
bruteforce reves up but hardly moves
,
mini bike runs but barely moves
,
motorcycle hardly moves in gear
,

when i press the troutle on my 2006 650h1 arctic cat i hardly moves

Click on a term to search our sites for related topics.

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


 

Garage Plus vBulletin Plugins by Drive Thru Online, Inc.