How to read engine codes! - ArcticChat.com - Arctic Cat Forum

Utility ATV repair and maintenance & Troubleshooting Place your Utility ATV Repair and Maintenance questions/thoughts here... *not performance*

 
LinkBack Thread Tools Display Modes
post #1 of 1 Old 05-11-2011, 02:57 PM Thread Starter
Team ArcticChat
 
400LE's Avatar
Team ArcticChat
 
Team ArcticChat
Join Date: Oct 2007
Location: Grafton, ND
Posts: 3,970
Thanks: 110
Thanked 519 Times in 322 Posts
ATV: 2009 700h1, 2013 1000XT H2
How to read engine codes!

thanks to quadman15 he told us how to check out engine codes and he sent it to me so i could pin it for him so here it is:

Here is how to pull up the codes, how to
reset all codes, how to reset the Idle speed
control and Throttle position sensor.

READ COMPUTER CODES

Key off

Insert Jumper pin in Diagnostic plug
Key on

Read codes on the

pod display

Key off

Remove the jumper pin

RESET COMPUTER CODES
Key off

Insert Jumper pin in Diagnostic Plug
Put in 4 wheel drive

Depress the Reverse Override Button
Key On

Pod will read AC-00

All codes have been reset

Key off

Remove jumper pin

SET THROTTLE POSITION SENSOR
Key off

Insert jumper pin in diagnostic plug
Key on

Loosen Throttle Position sensor retaining screw
Adjust Throttle position sensor until the mark
on the pod is centered

Tighten Throttle Position sensor screw
Key off

Remove Jumper pin

SET IDLE SPEED CONTROL
Key off

Insert jumper pin in diagnostic plug
Hold throttle open

Key on

Hold throttle open for 10 - 15 seconds
Key off

Here are what all the codes mean:

CODE DESCRIPTION
S C = Stored code A C=Active Code
AC00
No fault detected Active only
12
Crank position sensor *
13
Manifold Absolute Pressure
14
Throttle position sensor
15
Engine coolant temp sensor
16
Speed sensor
21
Inlet air temperature Sensor
23
Tilt Sensor *
24
Ignition coil #1 *
26
Ignition coil #2 *
32
Fuel injector #1 *
34
Fuel injector #2 *
40
Idle speed control
41
Fuel pump Relay
60
Cooling fan relay
95
Sensor power
96
Incorrect ECU *
97
ECU memory power
98
UART Comm Link
99
Start/Run not possible
*
Will initiate 99


The following message concerns resetting
various codes and clearing all codes




2009 ARCTIC CAT 700H1 TURNED MUDPRO
25.5" PITBULL ROCKERS
///AIRDAM CLUTCH
RTR FLEX-BRACKET
MUDPRO SNORKEL
HMF PERFORMANCE SERIES EXHAUST
POWER-COMMANDER V/AUTO-TUNE
6000K HID HEADLIGHTS
WATER TEMP GAUGE
MOTOSPORT ALL
OY WHEELS
PONDTUNES UNDERGLOW/REVERSE LIGHT
POWERMADD HANDGUARDS
NOLOGY COIL/HOTWIRE/PLUG
BAJA FRONT AND REAR BUMPER
ODI LOCK GRIPS
A FEW EXTRAS
CLUTCH WORK
28" TERMINATORS CRUSHED

2013 ARCTIC CAT 1000xt
9/28/13
WINCH
HANDWARMERS
DELUXE WINDSHIELD
RADIO w/KICKER SPEAKERS
6000K HID HEADLIGHTS
RAM CELL PHONE MOUNT
GENSSI 20" 120w LED LIGHT BAR

RUFF RIDERZ ATV CLUB
ONLY ATV CLUB IN NORTH DAKOTA





400LE is offline  
The Following 9 Users Say Thank You to 400LE For This Useful Post:
08ac700 (03-13-2012), Arcticcatgirl34 (05-11-2014), ArcticFrost (09-22-2014), groundman1 (05-20-2011), gymppi Team ArcticChat (04-12-2012), Mike R Team ArcticChat (08-05-2014), noubie (04-08-2016), rhinoexpress (09-17-2012), workinhardly (03-12-2017)
Sponsored Links
Advertisement
 
Closed Thread

  Lower Navigation
Go Back   ArcticChat.com - Arctic Cat Forum > ATV's > Utility ATV repair and maintenance & Troubleshooting

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the ArcticChat.com - Arctic Cat Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in









Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Similar Threads
Thread Thread Starter Forum Replies Last Post
How to read error codes + complete list of codes and what they mean (2009 - 2010) Nemi Pinned Topics 22 02-23-2017 03:18 AM
HELP!!! engine codes --- ec 2.2 or ec 22 not frickengreen Utility Performance / Technical info 3 08-16-2010 09:44 PM
Z1 TURBO ENGINE CODES PAPPA BEAR 4 Strokes 14 01-13-2009 11:36 AM
need help deciphering engine codes siudog Z/ZL/ZR/ZRT/Tcat/EXT/jag/cougar 0 12-08-2008 08:14 PM
Check Engine Codes StCroix XFR/Firecat/Sabercat 0 12-22-2006 03:30 PM

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome